Product ID:VELVALEX S/G ALKYD EN MID BASE
MSDS Date:05/23/1989
FSC:8010
NIIN:00N024844
MSDS Number: BMNXK

PRESERVATIVE PAINT CO

5410 AIRPORT WAY SOUTH
SEATTLE, WA 98108
US

Emergency Phone: 206-526-2121; 206-634-5252

Info Phone: 206-763-0300

Cage: 86589

PRESERVATIVE PAINT CO

80387 SEATTLE, WA 98108-1726 US

Cage: 86589

ALUMINUM SILICATE

CAS: 66402-68-4

NAPHTHA, LIGHT ALIPHATIC (PETROLEUM) (THIS MATL CONTAINS UP

CAS: 64742-89-8

KEROSENE; (MINERAL SPIRITS)

CAS: 8008-20-6

RTECS: OA5500000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

2-BUTANONE; OXIME

CAS: 96-29-7

RTECS: EL9275000

OSHA PEL 200 PPM;300 STEL

ACGIH TLV: 200 PPM;300 STEL

SILICA, CRYSTALLINE - QUARTZ (SILICA)

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

NAPHTHA, MEDIUM ALIPHATIC; (MINERAL SPIRITS)

CAS: 64742-88-7

OSHA PEL 500 PPM

ACGIH TLV: 500 PPM

XYLENE; (XYLOL)

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM;150 STEL

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGROINE; (VM & P NAPHTHA, ODORLESS MINERAL SPIRITS)

CAS: 8032-32-4

RTECS: OI6180000

OSHA PEL 300 PPM;400 STEL

ACGIH TLV: 300 PPM

TREATED CLAY; (ORGANOPHILIC CLAY)

CAS: 71011-27-3

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE NOSE/THROAT IRRIT. MAY CAUSE
NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY HDCH, DIZZINESS, NAUSEA,
STAGGERING GAIT, CONFUSION AND UNCONSCIOUSNESS. MAY CAUSE IRRIT OR
BURNING OF EYES. RPTD OR P RLNG LIQUID CNCT MAY CAUSE SKIN IRRIT
WITH DISCOMFORT AND DERMATITIS. CHRONIC: REPORTS HAVE ASSOC RPTD
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA:IARC - 2A
Effects of Overexposure:HLTH HAZ: OR PRLNG OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. OVERSPRAY AND MISTS
ARE PRIMARILY CONSIDERED A NUISANCE DUST. PIGMENTS ARE NOT NORMALLY
CONSIDERED HAZARDOUS WHEN PRESENT IN A PRODUCT MIXTURE.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS INVOLVING
SKIN, LIVER, KIDNEY, AND PULMONARY DISORDERS.

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP,
PREFERABLE MOUTH-TO-MOUTH. IF BREATHING DIFFICULTY PERSISTS OR
OCCURS LATER, CONSULT A PHYSICIAN. EYE: IMMED FLUSH W/PLENTY OF
WATER FOR A T LEAST 15 MIN. CALL MD. SKIN: WASH W/SOAP AND WATER.
IF IRRIT OCCURS, CONTACT MD. INGEST: IN THE UNLIKELY EVENT OF
INGESTION, CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING!

Flash Point Method:TCC
Flash Point:105F,41C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP TO
PROT FROM COMBUSTION BY-PRODUCTS. COOL CLOSED CONTAINERS WITH WATER
FOG TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. VAP IS DENSER
THAN AIR & CAN TRAVEL & COLLECT IN LOW SPOTS. ISOLATE FROM HEAT,
ELECTRICAL EQUIPMENT SPARKS & OPEN FLAME. (SUPP DATA)

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. PREVENT SKIN CONTACT AND BREATHING OF VAPORS. CONFINE AND
REMOVE WITH INERT ABSORBANT MATERIAL. USE SPARK PROOF TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
EXCESS HEAT, SPARKS & OPEN FLAME. KEEP CLOSURES TIGHT WHEN NOT IN
USE. STORE IN AN UPRIGHT POSITION TO PVNT LEAKS.
Other Precautions:GROUND CONTAINERS WHEN POURING. DO NOT STORE ABOVE
120 F. KEEP AND STORE OUT OF REACH OF CHILDREN. DO NOT SAND, FLAME
CUT, BRAZE OR WELD DRY COATING WITHOUT NIOSH/MSHA APPROVED
RESPIRATOR OR APPROPRIA TE VENTILATION.

Respiratory Protection:NIOSH/MSHA APPROVED PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR.
Ventilation:LOC EXHST: SUFFICIENT IN PATTERN & VOLUME TO KEEP VAPORS
BELOW APPLICABLE REQUIREMENTS. MECHANICAL (GENERAL):(SUPP DATA)
Protective Gloves:SOLVENT IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. COVERALLS,
SOLVENT IMPERVIOUS APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
DO NOT APPLY TO HOT SURFACES. CAN CAUSE SPONTANEOUS COMBUSTION.
(RAGS, ETC.) VENT: SAME. SPECIAL: USE EXPLOSION-PROOF MECH DEVICE
IF REQUIRED.

Boiling Pt:B.P. Text:365F,185C
Vapor Pres:5.0
Vapor Density:4.9
Spec Gravity:1.2
Evaporation Rate & Reference:0.13 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AND PIGMENTED COATINGS WITH CHARACTERISTIC
SOLVENT ODOR.
Percent Volatiles by Volume:51

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, SMOKE

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. ABSORB LARGE SPILLS WITH INERT MATERIAL. INCINERATE
OR DISPOSE ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REQUIREMENTS. D O NOT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.